![Reply](https://www.trailmanorowners.com/forum/images/buttons/reply.gif) |
|
10-25-2010, 09:07 PM
|
#1
|
Guest
|
Where is the wood?
I am under the impression from the videos on the Trailmanor site that the Trailmanor does not have any wood. However, after reading Mr Geek's reply in the General discussion about the Hold-Down latch pulling out it looks like wood is still being used.
I also read in one of the forums that starting on a certain model year, that wood was replaced with aluminum.
Does anyone know for sure if wood still being used and the locations that it is used at?
If it was discontinued starting with a certain model year, does anyone know what year?
Oh.... and thanks to everyone for your replies about hot/cold beds.
|
|
|
10-25-2010, 09:27 PM
|
#2
|
Site Team
Join Date: Feb 2003
Location: The mountains of Scottsdale, AZ, and the beaches of Maine
Posts: 10,175
|
There has been a lot of discussion, and this question has been addressed for a number of models and years. Rather than repeat it all, please use the Search tool on the term "wood" to bring it up. For example
http://www.trailmanorowners.com/foru...ead.php?t=8899
Bill
|
|
|
10-26-2010, 08:14 AM
|
#3
|
Guest
|
I can tell you this, according to a brief discussion with ed at the factory a few months ago, they are still using wood strips along the edges so that they have something to staple the seals to. I wish they would go to something that didn't rot though, these are notorious for rotting out.
John
|
|
|
10-26-2010, 09:42 AM
|
#4
|
TrailManor Master
Join Date: Jan 2022
Location: San Diego, California
Posts: 2,927
|
Quote:
Originally Posted by jhill30
I can tell you this, according to a brief discussion with ed at the factory a few months ago, they are still using wood strips along the edges so that they have something to staple the seals to. I wish they would go to something that didn't rot though, these are notorious for rotting out.
John
|
What to you base your last comment on ("these are notorious for rotting out"). My last TM was 12-years-old and had no such issues. I haven't seen any reports of it on this forum.
__________________
TrailManor Elkmont
640W solar- 230AH LiFeP04 Battery
|
|
|
10-26-2010, 02:51 PM
|
#5
|
Guest
|
sure, there have been several people, on this forum, that have reported having wood rot. including me.....
The seals are held on by staples into the wood. If the caulk that is on the upper shell is not checked frequently and replaced, then water can / will run down into the seals and rot out the wood that is holding them in place. I owned mine for 2 years before I discovered it. It is not noticeable until it is too late, or you get to prying around and find it. I noticed one of the screws pulling out on mine, and tried to screw it back into nothing....starting prying around and ended up replacing the entire upper shell seal and wood. Not a fun project..
John
|
|
|
10-26-2010, 08:24 PM
|
#6
|
TrailManor Master
Join Date: Jan 2022
Location: San Diego, California
Posts: 2,927
|
Quote:
Originally Posted by jhill30
sure, there have been several people, on this forum, that have reported having wood rot. including me.....
The seals are held on by staples into the wood. If the caulk that is on the upper shell is not checked frequently and replaced, then water can / will run down into the seals and rot out the wood that is holding them in place. I owned mine for 2 years before I discovered it. It is not noticeable until it is too late, or you get to prying around and find it. I noticed one of the screws pulling out on mine, and tried to screw it back into nothing....starting prying around and ended up replacing the entire upper shell seal and wood. Not a fun project..
John
|
Your trailer is a 2001 and has an all wood frame. There have been several posts about all wood framed trailers having wood-rot in the lower frames.
You made a statement, "they are still using wood strips along the edges so that they have something to staple the seals to." This was news to me and I haven't seen any posts about it on the aluminum frame trailers. I guess that I should have made that more clear.
__________________
TrailManor Elkmont
640W solar- 230AH LiFeP04 Battery
|
|
|
10-26-2010, 09:30 PM
|
#7
|
TrailManor Master
Join Date: Apr 2009
Location: Chandler, AZ
Posts: 277
|
I believe the "stapling strips" for the seals are all now made from plastic (perhaps as early as 2006). I base that opinion on some previous investigation that I did and posted at:
http://www.trailmanorowners.com/foru...ead.php?t=9234
Posts # 5, 7 and 9 discuss the findings and have some pictures.
Jerry
__________________
Essie, Jerry and Lil' Bit the Mini Schnauzer-(now replaced by TWO Mini Schnauzers, Sassy and Schotzi)
2010 TM 3326 loaded for 3 day trip, 4955# GTW, 26 gal. water, 9.5 gal. LP, 530# Tongue Wt., 15" Dual Axle, TST Tire monitor, Hensley Cub Hitch
2004 Suburban 1500, 11,100# CGVW
|
|
|
10-26-2010, 10:25 PM
|
#9
|
TrailManor Master
Join Date: Jan 2022
Location: San Diego, California
Posts: 2,927
|
Quote:
Originally Posted by spam4us
|
I missed that post (too busy working on my trailer ![Stick Out Tongue](https://www.trailmanorowners.com/forum/images/smilies/tongue.gif) ). That's the 1st post that I have seen like that (evidently, I don't read all of the posts)..
I wonder why they used wood there, of all places???????
Does anyone know what thickness the aluminum tubing is in the framing?
__________________
TrailManor Elkmont
640W solar- 230AH LiFeP04 Battery
|
|
|
10-27-2010, 06:41 AM
|
#10
|
Guest
|
as I stated before, it is my understanding from Ed at the factory, that they are still to this day using the wood (attached to the aluminum frame) where they have to staple the seals. Someone with a new TM might can verify this.
My '01 has mostly aluminum. There is wood around the door and where the seals are for sure. Probably other places as well, just haven't discovered it yet.
|
|
|
![Reply](https://www.trailmanorowners.com/forum/images/buttons/reply.gif) |
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|